# New Build in Tonopah, AZ: Tight Roof Valleys, Foundation Cracks and Missing Insulation

- Link: https://propertyinspectionsplus.com/new-build-inspection-tonopah-az/
- Published: 2026-10-25T03:42:34+00:00
- Author: homeinspectordan

Tonopah is way out west of the Valley, quiet desert with views that make the drive
worth it. This brand-new home had a private well and was in good shape inside, but
there were a few things the buyers needed to bring to the builder before closing.

## Ask about the well

The driveway goes right past a well. If you buy a rural property like this, ask 
the seller whether it is your private well or a shared or community well, and get
that in writing. I measured about 52 PSI of water pressure, which is fine for a 
well. Much lower and you start to notice it.

## The roof

 * **Tight valleys.** The tiles in the front valley were cut so tight that debris,
   including cut tile and a piece of flashing, was trapped in it. That holds water.
   Opening the valley a little lets debris wash down.
 * **A plumbing vent with no flashing.** One larger vent pipe had underlayment but
   no metal flashing or tile around it yet. That has to be finished before the first
   rain.
 * **Flat roof overhang.** On the patio flat roof, the roofing did not extend far
   enough past the edge in the middle. Water ponds at the edge of a flat roof, and
   without enough overhang it works its way behind the fascia.
 * Good news: bird blocking was installed, and the new underlayment looked great.

## A lot of foundation cracks

Small cracks in a new foundation and stucco are common. But here I was finding one
every 3 or 4 feet, all the way around, and some were wide. This was not a post-tension
slab, so I want the builder to explain them and document them before closing. Nobody
has even lived here yet. You do not want to move in wondering whether they will 
keep growing.

## Attic ventilation and insulation

I only found two soffit vents and two gable vents for the whole attic. That is very
little air movement, and it was already 90 degrees up there on a mild day. In the
summer the attic will cook.

Inside, my thermal camera told the rest of the story. The batt insulation was not
snug against the vaulted ceilings and walls, and there were cold and warm spots 
all over the house, plus heat around every can light. Gaps like these waste energy,
and with a 150-degree attic over a 75-degree room, they can cause condensation and“
ghosting” stains on the ceiling. Blown-in insulation fills gaps much better than
batts.

## Inside the house

 * The microwave vent fan blew right back into the kitchen because the shipping 
   flap was never removed from the outside vent.
 * A loose cabinet hinge and missing or misplaced cabinet screws. The holes should
   be filled.
 * Grout instead of caulk between the plastic tubs and tile walls. Those materials
   move differently, so it needs caulk.
 * Low, sputtering water flow at one shower.
 * Door stops that will crack the drywall when a door is swung hard.
 * The water heater was only reaching about 112 to 115 degrees, and there was no
   bollard to protect it from a car in the garage.

On a new home, I test every outlet I can reach, not just one per room. Nobody has
tested them before you move in.

## New construction inspections anywhere in Arizona

We are based in Gilbert and inspect new builds all over the state, from the West
Valley to [Casa Grande](https://propertyinspectionsplus.com/home-inspector-casa-grande-az/)
and [Maricopa](https://propertyinspectionsplus.com/home-inspector-maricopa-az/).
Learn more about our [new construction inspections](https://propertyinspectionsplus.com/new-construction-inspection/),
[thermal imaging](https://propertyinspectionsplus.com/thermal-imaging-inspection/)
and the [11-month warranty inspection](https://propertyinspectionsplus.com/11-month-warranty-inspection/).
Every home inspection includes a [termite (WDO) inspection](https://propertyinspectionsplus.com/termite-inspection/)
at no extra charge, plus a 1-year termite warranty through [Firehouse Pest Control in Gilbert](https://firehousepest.com/services/termite-treatment/)
if no active termites are found.

**Buying a home?** [Book your inspection online](https://app.spectora.com/home-inspectors/my-inspection-company-f8d6dbae4e/schedule)
or call [623-399-0079](https://propertyinspectionsplus.com/new-build-inspection-tonopah-az/6233990079).

Property Inspections Plus is a [Gilbert, AZ home inspection](https://propertyinspectionsplus.com/)
company led by Certified Master Inspector Dan Pierce. We inspect homes across the
East Valley, the Phoenix metro and the rest of Arizona. See all of our [service areas](https://propertyinspectionsplus.com/service-areas/).